Zipper RPE60 Uputstvo za upotrebu benzinske vibro ploče

1. Uvod

This user manual provides essential information for the safe and efficient operation, maintenance, and troubleshooting of your Zipper RPE60 Petrol Plate Compactor. Please read this manual thoroughly before operating the machine to ensure proper use and to prevent injury or damage.

The Zipper RPE60 is a robust petrol-powered vibrating plate designed for compacting various granular materials such as sand, gravel, and asphalt. Its compact design and powerful engine make it suitable for a range of construction and landscaping tasks.

2. Sigurnosna uputstva

Always prioritize safety when operating the plate compactor. Failure to follow these instructions can result in serious injury or death.

2.1 Opća sigurnost

• Pročitajte i razumite cijeli priručnik prije upotrebe.
• Wear appropriate Personal Protective Equipment (PPE), including safety glasses, hearing protection, sturdy footwear, and gloves.
• Do not operate the machine under the influence of alcohol, drugs, or medication that may impair judgment.
• Držite djecu i prolaznike podalje od operativnog područja.
• Ensure the work area is well-lit and free of obstacles.

2.2 Sigurnost goriva

• Gorivo sipajte u dobro prozračenom prostoru sa isključenim i hladnim motorom.
• Do not smoke or allow open flames near the fuel tank.
• Odmah obrišite proliveno gorivo.
• Store fuel in approved containers away from heat sources.

2.3 Sigurnost rada

• Operate the compactor on stable ground.
• Be aware of exhaust fumes; operate only in well-ventilated areas.
• Do not operate on slopes that are too steep, as the machine may tip.
• Nikada ne ostavljajte mašinu bez nadzora dok radi.

3. Komponente i kontrole

Familiarize yourself with the key components of the Zipper RPE60 Plate Compactor.

Slika 3.1: Front view of the Zipper RPE60 Petrol Plate Compactor, showing the engine, fuel tank, and compaction plate.

Slika 3.2: Side view of the Zipper RPE60, highlighting the handle assembly and transport wheels.

Slika 3.3: Close-up view of the engine on the Zipper RPE60, showing the air filter and recoil starter.

Ključne komponente:

• motor: Petrol-powered engine providing the necessary power for compaction.
• rezervoar za gorivo: Located on top of the engine, for petrol storage. Capacity: 3.6 litres.
• Compaction Plate: The heavy base plate that vibrates to compact the material. Dimensions: 35 cm (width) x 51 cm (depth).
• Sklop ručke: For guiding and controlling the compactor.
• Kontrola gasa: Adjusts engine speed and vibration intensity.
• Recoil starter: Za ručno pokretanje motora.
• Transportni točkići: For easier movement of the machine when not in operation.

4. Podešavanje i provjere prije rada

Before starting the compactor, perform the following checks to ensure safe and efficient operation.

4.1 Montaža (ako je potrebno)

The Zipper RPE60 typically comes partially assembled. Attach the handle assembly securely using the provided hardware. Ensure all bolts are tightened to the manufacturer's specifications.

4.2 Punjenje goriva

1. Provjerite je li motor isključen i hladan.
2. Otvorite poklopac rezervoara za gorivo.
3. Fill the tank with fresh, unleaded petrol (minimum 95 RON). Do not overfill.
4. Čvrsto zatvorite čep rezervoara za gorivo.

4.3 Engine Oil Check

1. Place the compactor on a level surface.
2. Pronađite mjernu šipku za ulje/čep za punjenje.
3. Remove, wipe clean, reinsert (without screwing in), and remove again to check the oil level.
4. Add recommended engine oil (e.g., SAE 10W-30) if the level is low, ensuring it reaches the full mark.
5. Čvrsto vratite mjernu šipku/čep za punjenje.

4.4 Opće provjere

• Inspect the air filter for cleanliness. Clean or replace if necessary.
• Check all nuts, bolts, and fasteners for tightness.
• Ensure the compaction plate is clean and free of debris.
• Verify that the throttle control operates smoothly.

5. Uputstvo za upotrebu

Follow these steps for safe and effective operation of your plate compactor.

5.1 Pokretanje motora

1. Ensure the fuel valve is open (ON position).
2. Pomaknite ručicu čoka u položaj "ČOK" (za hladan start).
3. Move the throttle lever slightly to the "FAST" position.
4. Čvrsto i glatko povucite ručku startera dok se motor ne pokrene. Ne dozvolite da se uže povuče unazad.
5. Nakon što se motor pokrene, postepeno pomaknite ručicu čoka u položaj "RUN".
6. Allow the engine to warm up for a few minutes before engaging compaction.

5.2 Compaction Procedure

Slika 5.1: An operator guiding the Zipper RPE60 Plate Compactor over a gravel surface, demonstrating typical use.

Slika 5.2: Drugi view of the Zipper RPE60 in operation, showing the operator's stance and control of the handle.

• Set the engine speed to the desired level using the throttle. Higher speeds generally result in greater compaction force.
• Guide the compactor slowly and steadily over the material to be compacted.
• Overlap each pass by approximately one-third of the plate width to ensure uniform compaction.
• For optimal compaction, make multiple passes over the same area, gradually increasing the number of passes until the desired density is achieved.
• The recommended compaction depth is up to 150 cm, with a movement speed of 13.8 meters per minute.
• For cohesive soils, it may be beneficial to lightly moisten the surface before compaction.

5.3 Zaustavljanje motora

1. Smanjite broj okretaja motora na prazan hod.
2. Pomaknite prekidač motora u položaj "ISKLJUČENO".
3. Close the fuel valve (OFF position) to prevent fuel leakage.

6. Održavanje

Regular maintenance is crucial for the longevity and optimal performance of your Zipper RPE60.

6.1 Dnevno održavanje

• Clean the compactor thoroughly after each use, removing dirt and debris from the plate and engine area.
• Provjerite nivo motornog ulja.
• Pregledajte filter zraka na prekomjernu prljavštinu.
• Provjerite ima li labavih pričvršćivača i zategnite ih po potrebi.
• Inspect the V-belt for wear or damage.

6.2 Periodično održavanje

• Every 25 hours or monthly: Clean/replace air filter. Check spark plug; clean or replace if fouled.
• Every 50 hours or 3 months: Change engine oil. Inspect fuel filter.
• Every 100 hours or 6 months: Inspect valve clearance (professional service recommended). Clean fuel tank.
• Godišnje: Full service by a qualified technician.

6.3 Skladištenje

For long-term storage, drain the fuel tank and carburetor. Remove the spark plug and add a small amount of engine oil into the cylinder, then pull the recoil starter a few times to distribute the oil. Store the compactor in a clean, dry place.

7. Otkrivanje problema

This section provides solutions to common operational issues. For problems not listed here, contact qualified service personnel.

8. Tehničke specifikacije

9. Informacije o garanciji

Zipper products are manufactured to high quality standards. For specific warranty terms and conditions, please refer to the warranty card included with your product or visit the official Zipper webSačuvajte dokaz o kupovini za eventualne reklamacije.

10. Korisnička podrška

If you require technical assistance, spare parts, or have questions regarding your Zipper RPE60 Plate Compactor, please contact your authorized Zipper dealer or the customer service department. Refer to the contact information provided with your purchase documentation or on the official Zipper website.

For general inquiries, you may also refer to the seller "Scheppach Direct UK" if purchased via Amazon, as indicated in the product listing.